AUTONET TV

Hold the Oil! (Oil Pan Gasket Replacement)

You've likely heard how important oil is to your vehicle's engine. Did you know that there's one part that's responsible for holding that oil so you can use it every day? It's called the oil pan, and it sits at the bottom of the engine.

The oil pan is a vital, though simple, part of your engine's lubrication system. Oil circulates through parts of your engine to keep them lubricated. It reduces friction so everything works smoothly. Without oil, friction would quickly destroy your engine. The oil pan keeps that oil contained in the lubrication system, so it's important that the oil doesn't leak out. Since it's a metal part attached to another metal part, there is a gasket between the oil pan and the part of the engine it attaches to.

Various things can put stress on the oil pan and gasket, including weather extremes, the speed you're traveling and the condition of the oil. You may drive over a couple of bad roads and kick up debris onto your oil pan. All this wear and tear, heat and time can take their toll. So after a while, the gasket can just wear out and start leaking. It usually starts pretty slowly. If you see oil visible under your vehicle where you park it, that might be a sign of a leaky oil pan gasket. Another sign? You smell burning oil coming from your engine. If the leak is bad and your engine has lost a lot of oil, you may eventually see the oil light go on.

Let your service advisor know if you are experiencing any of these things. Driving with insufficient oil can badly damage your engine. And it can do it quickly. A Kingwood Service Center trained technician will check to find the source of the leak. It may just be a gasket, but it also could be the oil pan is damaged and needs replacing as well.

This is a repair you should get taken care of. Your engine needs its lubrication system intact to provide you many years of service.

Kingwood Service Center
3318 Northpark Dr
Kingwood, TX 77339
(281) 360-7323
http://www.kingwoodservicecenter.net

A Stitch in Time at Kingwood Service Center

You probably have heard that expression, "A stitch in time saves nine." In other words, if you fix an issue at its early stages, it will prevent a much more difficult problem later. That's certainly the case with your vehicle, and here's a true story to demonstrate it.

A driver noticed his vehicle was due for an oil change, so he took it in to his service facility early in the morning so he could wait while the work was performed. The technician routinely checks the battery on vehicles just before extreme weather is approaching (cold or hot), so with winter coming up, he hooked up the load tester (it measures voltage while a load is put on the battery). It showed the battery wasn't holding a charge well.

The technician checked the manufacturing date on the battery, too (most batteries have a date stamped in code somewhere on them). The date showed it was five years old. While batteries can last more than five years, many technicians say you should expect to get anywhere from three to six years out of them, depending on what they go through.

So, this battery was getting a little long in the tooth, and it wasn't holding a charge particularly well. But how much current was it being sent by the vehicle's alternator? If it wasn't getting enough, that might be a factor. A test of the charging system showed the alternator was putting out the correct amount of power. The technician recommended replacing the battery, and the driver agreed.

That was the stitch in time. Had the technician not checked the battery, that driver likely would have been stranded the next time he tried to start his vehicle on a very cold day. What originally was supposed to be just an oil change led to a technician's sharp diagnosis and a little preventative maintenance for one fortunate driver. Sometimes timing is everything.

Kingwood Service Center
3318 Northpark Dr
Kingwood, TX 77339
(281) 360-7323
http://www.kingwoodservicecenter.net